A Tribute To Resistance

November 14, 2018

The rig, Treasure Saga was built in 1984 in Sweden and eventually went to work for Saga Petroleum AS in the Norwegian sector of the North Sea

 

In the fall of 1988 Saga was drilling

the  2/4-14 in the general area of Ekofisk Field in 68 meters of water. Its partners in the well were Statoil, Elf Aquitiane and Amerada Hess. The well encountered  an over pressured zone at 4,733 meters in open hole below its 9 5/8ths intermediate casing shoe at 4,448  meters.

 

Multiple attempts were made to kill the well with mud before cementing the BHA in place in hopes of  backing  off  the drill pipe  and sidetracking. In the  back off procedure  the 5 inch  DP  was found to be obstructed.  During coiled tubing efforts to remove the  obstruction the coiled tubing became stuck and eventually parted. At that time  PLT logs determined that a sub-surface blowout was underway.  The DP and  coiled tubing  were both sheared and the sub-sea BOP stacked closed.

 

The Treasure Saga was moved off the well to commence relief well operations by the John Wright Company. The rig, Neddrill Trigon was moved to the 2/4-14 well and tied back to the surface via a HP riser where Boots and Coots, Inc., including Boots Hansen and my friends, Martin Kelly and Joe Carpenter, assumed the responsibility of snubbing operations to fish the coiled tubing and DP. Months of impression block, overshot, dress mills and fishing efforts were made all via snubbing units with surface pressures ranging from 10K PSI to 2,900 PSI below both sub sea and surface BOP's, as well as the snubbing unit.  Everything bad that can happen in the oilfield did happen on this well including, ultimately, parted DP, two separate fish stuck in open hole, parted 9 5/8ths casing and H2S induced casing failure above the part. Surface intervention continued while the 2/4-14 S well, using the Treasure Saga, drilled toward intersection of the blowout well. Additional PLT logs run in the 14 blowout well above parted DP showed the flow into the sub surface was over 18,000 BOPD.

 

In mid December 1989, almost 12 months after the initial kick occurred in the No. 14, John Wright  used the 14 S relief well to intersect the blowout well at a depth of 4705 meters;  it was killed and cemented to smithereens. bottom, up, as was the relief well. The Neddrill Tirgon was moved off the 14 (R) and the Treasure Saga moved back on the well to finish fishing, setting cement plugs and cutting and retrieving casing below the mud line for abandonment. The rig was released in April of 1990. Total accumulated costs to kill the blowout exceeded $285,000,000 USD.   

 

The Treasure Saga thereafter worked along the Norwegian Continental Shelf until 1998 when she was bought by Transocean and rechristened the Transocean Winner. After upgrading in 2006 she continued her illustrious career in the North Sea under primary contract to StatoilHydro and was retired in 2016.

 

In tow to Malta to be decommissioned she broke loose her toe lines in heavy weather and on August 8, 2016   went hard aground on the Isle of Lewis in the Outer Hebrides off the Scottish coastline.

 

 

She lost diesel from a ruptured fuel tank. During  extreme high tide she was refloated two weeks later but it required  three  attempts to  pull her off the rocks. The Winner was then towed to  a remote bay on the east coast of Scotland where even then she refused to go down without a fight. It  took two attempts to load her onto a heavy lift ship and she almost capsized when ballast in her legs ruptured.  Eventually she made her way to Turkey where she was finally cut up into scrap and laid to rest. 

 

______________________________________________________________________________

                                                                                                          

 

"A great ship asks deep water."

George Herbert

 

                                                                                         Treasure Saga, 1983-2016; North Sea

 

 

 

___________________________________________________________________________________

 

Author's note:

 

I don't blog for a living; I operate a bunch of oil and gas wells and work 24/7, ranch, take care of my family and play tough, competitive tennis. I was born in the oilfield, literally; it is very much part of who I am. Its history, culture and traditions I like to share with people because soon that history will all be lost, forever. I research and write in between other demands because I enjoy it, particularly when its cold outside. I am from South Texas and cold weather and I don't see eye to eye. 

 

I heard stories of the Saga blowout while working for Boots and Coots, Inc. in the mid 1990's and while researching the event  discovered the very same rig involved in that blowout eventually got her name changed and went aground off Scotland. It was a cool discovery and I had fun  writing this piece.  The rig, Treasure Saga had a troubled past, but she also made a great contribution to North Sea  oil and gas development and I thought it ironic, and somehow a little sad, she seemed to want to 'fight' to the very end of her life. She...resisted. Maybe all this is a little more about me than this damn rig.

 

To write this I relied on stories from Martin Kelly, Boots Hansen's book, an SPE paper co-authored by John Wright, post geophysical  reports regarding oil and gas migration from the blowout, actual daily well reports from Saga itself and the internet for photographs. My apologies to anyone actually involved in these events for whatever mistakes I may have made.

 

Mike

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Share on Facebook
Share on Twitter
Please reload